Rib Plating as an Effective Approach to Managing Traumatic Rib Injuries: A Review of the Literature – Cureus

The rate of mortality secondary to chest trauma is estimated to be 20%-25%, with elderly adults succumbing to their injuries more often than younger patients [1-3]. Rib fractures, the most common traumatic thoracic injury have long been a significant cause for concern due to their high incidence in the general population (20%-39%) and associated morbidity and mortality (10%-15%) [4,5]. Common complications of rib fractures include pulmonary contusions, flail chest (FC), and atelectasis, which can lead to acute respiratory failure (ARDS) [6]. Rib fractures are also associated with life-threatening conditions such as pneumothorax, hemothorax, and blunt cardiac injury. Patients who do recover from rib fractures can be affected for several months after the injury [7]. Despite this knowledge, the standard approach to treating rib injuries has traditionally been via conservative management with pain control optimization, use of positive pressure ventilation, pulmonary hygiene, chest physiotherapy, and frequent mobilization [3,8,9]. Rib fractures managed conservatively can suffer gradual displacement during the recovery phase and thus yield deformity, degeneration, and respiratory complications [6,10]. Current literature suggests that, when indicated, conservative management has generally been less effective than surgical stabilization in managing these patients long-term and therefore resulted in substantial hospital and societal costs [11].

Many studies in the literature suggest that rib stabilization using a plating system has shown the potential in reducing immediate and long-term complications of rib fractures, including the development of pneumonia, the need for tracheostomy, prolonged hospitalization,increased dependence on pain medication, and mortality from FC. Currently, there are multiple indications and contraindications for rib fracture stabilization as outlined in the 2020 guidelines by the Chest Wall Injury Society (CWIS) [12].

Indications include chest wall instability: either FC, the presence of at least three consecutive ribs broken in two locations, or three consecutive bi-cortically displaced rib fractures [4,12]. This is applicable to both ventilated and non-ventilated patients [12].The procedure has also been used in ventilated patients who fail to wean from the ventilator with or without FC, non-ventilated patients with three or more severely displaced acute rib fractures in ribs 3-10 in combination with two or more pulmonary physiologic derangements despite loco-regional anesthesia and multi-modal pain therapy [12].Further indications for rib fracture stabilization include patients with implosion chest wall injuries (i.e., stoved-in chest), patients undergoing thoracotomy for another indication such as hematoma evacuation, or patients with greater than 30% loss of chest volume [10,12,13]. However, it is recommended that these indications be considered on a case-by-case basis due to limited support for their use in various studies [12].

Absolute contraindications include shock or incomplete resuscitation, fractures outside of ribs 3-10, severe traumatic brain injury (TBI), and acute myocardial infarctions [12,14]. Relative contradictions include age less than 18 and significant co-morbidities such as cardiopulmonary disease, mild to moderate TBI, active malignancy, spinal cord injury, empyema, or a history of chest wall radiation [12].

The plating system uses titanium plates that individually conform to patients ribs and protect against instability and nonunion (Figures 1, 2A, 2B). Though rib plating has the potential to modernize the management of rib fractures, it remains a second-line treatment for conservative management. A survey conducted by Mayberry and colleagues in 2009 revealed that rib plating was underutilized because the published literature on the technique was sparse and unfamiliar to most surgeons [15]. In 2014, Dehghan et al. performed a retrospective analysis on traumatic FC injuries using the National Trauma Data Bank which showed that only 0.7% of patients were treated with surgical fixation of the chest wall [9]. Although lack of procedural familiarity may explain this finding to some extent, the researchers cite the years in which the study population (2007-2009) was selected as a possible reason for this finding with fewer rib fixation procedures likely occurring during those years [9].Herein, we focus primarily on the plating system as an effective surgical approach to stabilizing patients with traumatic rib injuries.

We aimed to identify the use of rib plating as an effective surgical procedure for the management of traumatic rib injuries compared to the current standard of care in which patients are managed conservatively with pain control optimization, use of positive pressure ventilation, pulmonary hygiene, and frequent mobilization.For the purposes of this study, the efficacy of rib plating is defined by primary outcomes: ICU LOS, HLOS, ventilatory requirements, and mortality rates, and secondary outcomes: postoperative pain level and postoperative complications.

A literature search in the PubMed, Google Scholar and PLOS One databases was conducted between August 2021 and April 2022 using the following Medical Subject Heading terms: rib plating, rib stabilization, and surgical rib fixation. The search was limited to the English language with publication dates between January 2005 and December 2021 (one exception was a randomized control study [RCT] by Tanaka et al.). Only relevant articles with free full access were included in our review while case reports, case series (except for an article by Wijffels et al.), systematic reviews, and abstract-only articles were excluded. The authors independently reviewed potentially eligible titles and abstracts and contributed to the review process. Disagreements between the reviewers were infrequent and resolved by majority consensus. Where applicable, articles not meeting the inclusion criteria were then excluded from the study.

A total of 704 titles and abstracts from the PubMed, Google Scholar, and PLOS One databases were assessed for eligibility. Non-relevant articles were excluded which narrowed our search to 101 articles. Of these, 67 articles were repeated and were excluded, and the remaining 34 papers were assessed in detail for study inclusion (Figure 3).

Few RCTs demonstrating the efficacy of rib fixation exist. In one such study by Tanaka et al., 37 FC patients were randomized into a conservative group (n = 19) or surgical group (n = 18) five days post-injury [16].Indications for mechanical ventilation included the presence of hypoxia and/or hypercarbia (PaO2 < 60 mm Hg, PaCO2 > 50 mm Hg) under 40% inspired oxygen inhalation, associated severe trauma with unconsciousness and/or shock state, and presence of airway obstruction or repeated atelectasis [16].Both patient groups were managed equally leading up to surgery. Outcomes revealed a shorter ventilatory period (10.8 3.4 days vs. 18.3 7.4 days, p < 0.05), trauma intensive unit stay (16.5 7.4 days vs. 26.8 13.2 days, p < 0.05), postop pain at 12 month follow up (39% vs. 89%, p < 0.05), and lower incidence of pneumonia at three weeks post injury (22% vs. 90%, p < 0.05) in the surgical group [16].

In another RCT by Granetzy et al., 40 patients with FC were randomized for conservative management (using strapping, packing, and mechanical ventilation) or surgical treatment [10]. Patients with head trauma with disturbed conscious level, associated injuries such as myocardial contusion, severe trauma to other systems, and fractures of the upper three ribs only, were excluded from the study [10]. All surgical patients were operated on within 24-36 hours after admission. Prior to this, these patients were managed similarly to the conservative group [10]. After management of both groups, the researchers found that chest wall stability occurred in 85% of surgical patients compared to 50% in the conservatively treated group [10].Primary outcomes were lower in the former group compared to the latter (p < 0.001), except for the mortality rate which was non-significant between the two groups [10].

In a third RCT by Marasco et al., 46 mechanically ventilated patients with FC were randomized to a surgical group or conservative group [17]. Like Tanaka et al. and Granetzy et al., results showed lower total ICU stay (324 (238 - 380) hours vs. 448 (323 - 647) hours, p = 0.03) in surgically treated patients compared to conservatively managed patients [17]. Furthermore, the surgical group required less ventilation post-extubation (3 (0 - 25) hours vs. 50 (17 - 102) hours) [17]. Postoperative pain levels were not specifically assessed and complications such as pneumonia were not statistically significant between the two groups (48% vs. 74%, p = 0.07) [17].

In a more recent RCT by Pieracci et al., the researchers performed a multicenter study assessing the efficacy of rib fracture stabilization in patients with non-FC (NFC)injuries [18]. This study represents the first prospective, multicenter trial focused on the stabilization of NFC. Patient inclusion criteria were centered on CWIS guidelines. The presence of FC, age < 18 or 80 years, moderate to severe TBI, and enrollment > 72 hours post injury were amongst the exclusion criteria [18]. The initial sample size consisted of 848 patients; however, 87% of patients failed screening resulting in an enrollment of 110 patients. The most common reasons for screening failure were fewer than three displaced rib fractures (30.3%) and less than 50% displacement of fractures (21.3%) [18].Patients who failed screening, as compared those who were enrolled, were more likely to be female (34% vs. 25%, respectively), older (58 vs. 55 years, respectively), and have a lower injury severity score (ISS 9 vs. 14, respectively) [18].Results of the study showed no difference in ICU LOS, HLOS, or median ventilator days between the surgical and conservative groups and no mortality occurred in either group [18].Surgical management was associated with lower numeric pain scores (NPS) as early as hospital day 7 (4.7 vs. 6.3, p < 0.01) [18]. This held true at week two follow up (2.9 vs. 4.5, p < 0.01), and at four weeks and eight weeks follow up (2.4 vs. 3.3, p < 0.03) and (1.5 vs. 3.3, p <0.02), respectively. NPS on hospital days 1-6 were non-significant [18]. Pleural space complications were found to be lower in the surgical group compared to the conservative group (0% vs. 10.2%, p = 0.02) while pneumonia rates were non-significant between the two groups (2.0% vs. 6.7%, p = 0.37) [18]. Overall, results from this study underscore a more modest benefit to rib fixation in the NFC population compared to those seen amongst the FC populations in previous RCTs.

In a study conducted by Taghavi et al., 114,972 patients with rib fractures were classified as having FC (n = 5,106), multiple rib fractures (MRF) (n = 85,140), or a single rib fracture (SRF) (n = 24,726) [19]. The median age (in years) of patients in each group was 57.0, 56.0, and 50.0, respectively. Females comprised 24.9% of participants with FC, 32.3% of those with MRF, and 31.2% of those with SRF [19].In total, 98.6% of study participants were treated conservatively while 1.4% were treated surgically. Amongst in-hospital patients, those who underwent surgical stabilization were found to require longer HLOS (5.0 vs 13.0 days; p < 0.001), ICU LOS (4.0 vs 8.0 days; p < 0.001), mechanical ventilation (19.5% vs. 40.6%; p < 0.001) and develop higher rates of ARDS (3.1% vs. 1.0 %; p < 0.001) compared to patients treated conservatively [19]. However, the authors posit that this is likely attributed to a marker of severe injury as these patients were more likely to have FC and high ISS [19]. Mortality rates, however, were lower in patients who underwent surgical stabilization compared to patients managed conservatively (2.5% vs. 4.8%, p < 0.001) [19].Similar findings were reported in a retrospective cohort study by Farquhar and colleagues [20]. The authors reported that the conservatively managed group had significantly better outcomes than the surgical group regarding ventilation requirements (3.1 vs. 6.1 days, p = 0.012), ICU LOS (3.7 vs. 7.4 days, p = 0.009), total HLOS (16.0 vs. 21.9 days, p = 0.044) and rates of pneumonia (22% vs. 63%, p = 0.004) [20]. However, there were no significant differences in long-term complications, such as chest pain or dyspnea [20].

Conversely, other studies have reported improved clinical outcomes in patients undergoing rib plating compared to conservative management. In their retrospective analysis, Liu et al. evaluated the clinical effects of MRF treatments using rib plating and found that the surgical group experienced fewer ICU LOS and HLOS than the conservative group (4.02 1.41 vs. 5.06 1.80 days, p = 0.001) and (13.12 4.21 vs. 18.57 5.39 days, p < 0.001), respectively [21]. In a second study by Xu et al., better short-term outcomes were observed in the surgery group, such as total mechanical ventilation time (10.5 3.7 vs. 13.7 4.4 days, p = 0.03), ICU LOS (15.9 5.0 vs. 19.6 5.0 days, p = 0.05), and Acute Physiology and Chronic Health Evaluation (APACHE II) scores on the 14th day (6.5 3.8 vs. 10.1 4.7, p = 0.02) [5]. Comparable results were echoed in a study by Zhang et al., who found fewer mechanical ventilation needs, shorter ventilation time, shorter HLOS, lower incidence of respiratory complications and thoracic deformity, and improved pulmonary function in post-surgical patients compared to those treated conservatively [22].

Yet, another study reported that HLOS, ICU LOS, duration of mechanical ventilation, and mortality were higher in the conservative group compared with those managed surgically (p < 0.001, p < 0.001, p < 0.001, and p = 0.027, respectively) [23]. However, there was no statistical difference in complications such as pneumonia or sepsis between patient groups [23]. In a study by Griffard et al., the authors matched the outcomes between operative and conservative management and found no difference in the prevalence of pneumonia (p = 0.1416) or severe ARDS (p = 0.999) between groups [24]. Furthermore, there was no significant difference between the operative and conservative groups in ventilator days (p = 0.641) or hospital days with 11 days vs. 9 days (p = 0.1358) [24]. Patients undergoing rib plating experienced longer ICU LOS at six days (IQR 4 to 9) compared with 3.5 days (IQR 2 to 9) in conservatively managed patients (p = 0.0217) [24]. Jayle et al. found no significant differences between groups for matched data and prognostic scores: ISS, revised trauma score, and trauma injury severity score [25]. However, ventilator time (142 224 vs 74 125 hours, p = 0.026) and overall HLOS (142 224 vs 74 125 hours, p = 0.026) were significantly lower for the surgical group after adjustment on prognostic scores [25]. Beks et al. found that rib fixation was not associated with ICU LOS (for FC patients) nor with HLOS (for MRF patients) while Olsn et al. and Farquhar et al. reported that there were no significant long-term differences between patients treated surgically and conservatively [20,26,27].

When comparing postoperative pain relief between surgical and conservative patients, Aababaolu and Ersz reported that pain scores were statistically significantly different in favor of the surgical group compared to the conservative treatment group (p = 0.0038 and p = 0.044, respectively) [23]. In a prospective study assessing the impact of plating in patients with rib fractures, the authors evaluated 67 patients over one year and classified them into conservative and operative groups based on a pain scale in which those with levels 5, 6, or 7 pain received conservative management, while patients with levels 8, 9, or 10 received operative management [28]. Results showed that patients undergoing surgical stabilization with plating had reduced pain and duration of disability and an increased return to work compared to the conservative group [28]. In their study aimed at investigating the curative effect of surgical treatment for 39 patients with severe NFC rib fractures, Zhang et al. found that these patients had better pain control and quality of living following surgery compared to the 39 patients that received conservative treatment with analgesia [29]. This held true at 72 hours, one week, two weeks, four weeks, six weeks, three months, and six months postop (p < 0.001) [29]. Caragounis et al. reported that surgical patients had significant outcome improvements at one-year postop concluding that final outcomes of surgical stabilization could not be finalized any sooner than this time period [30].

Though there have been previous studies detailing various rib plating systems and their application in the setting of FC, high-quality studies on NFC patterns are limited. It has been applied in patients with slipping rib syndrome, severe chest trauma associated with FC, concomitant lung lesion, serious alteration of the chest shape, and persistent and chronic pain that affects normal life [13,31]. Many studies suggest that this technique has been associated with earlier ambulation, shorter hospital duration, less opioid dependence, and greater patient satisfaction.

The most frequently reported post-surgical complications are related to underlying injuries from rib trauma, such as pulmonary contusion and pneumonia [7,32]. Rarer complications, including hardware infections, have also been reported to occur in 1-3% of patients [7,33]. As a result, it is necessary to drain any empyema that develops, initiate antibiotics, and remove the affected hardware once bacterial counts have lessened [7]. In contrast, if the fracture site is well healed, the hardware may be removed at the initial signs of complication [7]. Additional complications known to exist include wound hematoma, pleural effusion, post-thoracotomy pain syndrome, and osteomyelitis [10,28,32].

There are limited reports assessing the long-term outcomes of rib stabilization. One such study by Uchida et al. surveyed 20 patients (FC, n = 9; MRF, n = 11) who had undergone rib plating over a five-year period and assessed their quality of life [34]. The median follow-up duration was 47.5 months and the least desirable event occurring during the study period was irritation caused by a palpable plate in two of the participants [34]. Eighteen patients returned to baseline activity level without any complaints, two patients continued to undergo rehabilitation due to concomitant fractures of the extremities, and zero patients experienced implant-related complications requiring explantation [34].

Questions still exist regarding the effect rib stabilization has on ICU LOS. Fokin et al. and Griffard et al. observed longer ICU LOS for those who had surgical rib stabilization while a study by Xiao et al. found that surgical rib fixation shortened ICU LOS in patients with MRF and FC, but it did not in those without FC [24,35,36]. Majeed et al. found no statistical difference in HLOS or the number of days for ventilator support and findings on ICU LOS were not reported [37]. Acker et al. reported there to be no statistical difference in HLOS, ICU LOS, and mortality rates between surgically treated patients and conservatively treated patients [38]. However, there was notable clinical improvement in ventilation in patients with FC and MRF following surgical stabilization [38].

Discussions on surgical timing have been extensively covered in the literature. Many studies recommend that operative repair occurs within the first 48-72 hours post-trauma as inflammation and callus formation have yet to occur, resulting in an easier operation [12,35,39]. When comparing surgical timing in patients undergoing rib fixation within three, six, or 10 days after hospital admission, Otaka et al. found that surgical rib fixation within three days after admission was associated with a shorter duration of mechanical ventilation (percent difference, -42.9%; 95% CI, -57.4 to -23.3) and shorter HLOS (percent difference, -19.6%; 95% CI, -31.8 to -5.2) [40]. However, there were no significant differences between the groups in all-cause 28-day in-hospital mortality (risk difference, -0.02; 95% CI, -0.07 to 0.03) or in any in-hospital outcomes between those who had and had not undergone rib fixation within six or 10 days after admission [40].

Similarly, Su et al. also analyzed the impact of early (stabilization within three days of injury) versus late (stabilization after three days of injury) surgical stabilization on perioperative and clinical outcomes in 33 patients with severe rib injuries [41]. Sixteen of the patients underwent early stabilization and 17 underwent late stabilization [41]. Results showed that patients receiving early intervention had a notably shorter duration of mechanical ventilation (median = 36 vs. 90 hours, p = 0.03), ICU LOS (median = 123 vs. 230 hours, p = 0.004), and HLOS (median = 12 vs. 18 days, p = 0.03) compared to patients who underwent late surgical repair, though mortality rates were nonsignificant between the groups [41]. Descriptions of each study are listed in Table 1. Primary and secondary outcomes of the various studies are reported in Tables 2,3, respectively.

With the rise of rib fixation, a surge in rib fixation systems has also occurred. Examples include intramedullary nails or splints, Kirschner wires, plating, and Judet struts. However, our paper focused primarily on the efficacy of the plating system compared to the current standard of care. Therefore, the outcomes reported herein are not necessarily generalizable to other forms of surgical stabilization excluded from this paper. Which system is best, remains to be seen. Additionally, our findings addressed the overall use of rib plating and did not aim to distinguish between the preferences or success rates of various manufacturer products (i.e., MatrixRIB vs. RibLoc vs. Stratos). Future research comparing the efficacy of these stabilization systems is necessary to better demonstrate superiority in clinical outcomes.

Another limitation is that our search of the literature was limited to PubMed, Google Scholar, and PLOS One search engines which may have limited the results reported in our paper compared to if additional search engines were utilized. Furthermore, only full-text articles with free access were considered for inclusion which narrowed the number of potentially relevant articles that would otherwise have met our inclusion criteria. Likewise, except for an article by Wijffels et al., we excluded over 20 case reports/case series as findings reported in these sources could have low external validity and thus not be helpful in establishing a cause-effect relationship. This could lead to over-interpretation of findings. Additionally, most of the studies referenced in this paper consisted of smaller sample sizes which decreasethe power of statistical comparisons and may account for type II errors. Other considerations affecting the outcomes of rib plating are whether chest wall injuries occurred in isolation or polytrauma. We found that certain studies reported a difference in rib plating outcome when traumatic rib injuries occurred in isolation compared to in the settings of comorbidities such as pulmonary contusion, FC, and severe TBIs.Lastly, only eight of the studies included in this review were prospective in nature, therefore, increasing potential sources for bias and confounding herein.

More here:
Rib Plating as an Effective Approach to Managing Traumatic Rib Injuries: A Review of the Literature - Cureus